by
Fruit andVegetable
Processor & Juicer
Instruction Manual
Item # AJ-1400-BL
120V ~ 60Hz 320W
Thank you for your purchase of The Biggest Loser™ Fruit andVegetable Processor
& Juicer. Please READ this instruction manual carefully before use.
SAVETHESE INSTRUCTIONS
TABLE OF CONTENTS
Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Special Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Descriptive Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Using your Fruit and Vegetable Processor & Juicer . . . . . . . . . .7
Using the Extractor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Using the Citrus Juicer . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Cleaning and Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . .9
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
3
IMPORTANT SAFEGUARDS
When using electrical appliances, basic safety precautions should always be fol-
lowed, including the following:
1. READ ALL INSTRUCTIONS COMPLETELY BEFORE USING.
2. To protect against electrical shock do not immerse cord, plugs or this appli-
ance in water or any other liquid.
3. Close supervision is necessary when any appliance is used by or near children.
4. Unplug from outlet when not in use, before putting on or taking off parts and
before cleaning. Allow to cool completely before touching. Make sure the
motor stops completely before disassembling.
5. Avoid all contact with moving parts;keep hands, hair, loose clothing and
utensils away from the unit during operation to prevent injury and/or damage
to the appliance.
6. Do not operate any appliance with a damaged cord, plug, rotating sieve or
after the appliance malfunctions, or is dropped or has been damaged in any
manner. Return the appliance toTaylor® (see warranty) for examination, re-
pair or adjustment.
7. Do not use attachments that are not supplied for this appliance fromTaylor®.
The use of accessory attachments not recommended byTaylor® may cause
fire, electric shock, injuries or permanently damage this product. Only use
the containers that are supplied in this unit.
8. Do not use outdoors.
9. Do not let cord hang over edge of table or counter, or touch hot surfaces in-
cluding the stove.
10. Ensure the unit is completely assembled before using. Always make sure the
juicer cover is clamped securely in place before the motor is turned on. Do
not unfasten the clamps while the juicer is in operation.
11. Be sure to turn the switch to the OFF position after each use of the juicer.
Make sure the motor stops completely and the unit is unplugged before disas-
sembling.
12. Never feed food by hand. Do not put your fingers or other objects into the
juicer opening while it is in operation. If food becomes lodged in the open-
ing, use the food pusher or another piece of fruit or vegetable to push it
down. When this method is not possible turn the motor off, unplug and dis-
assemble the juicer to remove the remaining food.
13. Do not use the appliance if the rotating sieve is damaged.
14. Blades are sharp;handle very carefully.
15. To disconnect, be sure the unit is off, then remove the plug from the wall out-
let by grasping the plug and pulling. Never unplug the appliance by pulling
on the cord.
16. When using this appliance, provide adequate air space above and on all sides
for air circulation.
17. Do not place this appliance near a hot gas or electric burner or in an oven.
4
18. Do not leave the appliance unattended during use.
19. Do not use this appliance for other than its intended use.
SAVETHESE INSTRUCTIONS
SPECIAL INSTRUCTIONS
This appliance is for HOUSEHOLD USE ONLY.
•
This appliance has a polarized plug (one blade is wider than the other). To re-
duce the risk of electrical shock, this plug will fit in a polarized outlet only one
way. If the plug does not fit fully in the outlet, reverse the plug. If it still does
not fit, contact a qualified electrician. Do not modify the plug in any way.
Make sure the voltage in your outlet is the same as the voltage indicated on
the appliance. This appliance is for 120 –Volt AC electrical outlet only.
The length of the cord used on this appliance was selected to reduce the haz-
ards of becoming tangled in, or tripping over a long cord. For safety, it is not
recommended to use an electrical extension cord with this appliance.
Do not immerse base of unit, plug or cord in water or other liquids.
Use with wall receptacle only.
•
•
•
•
•
Do not attempt to service this unit yourself.
INTRODUCTION
Now you can learn how to prepare and enjoy great tasting, healthy meals in min-
utes using your The Biggest Loser™ Fruit andVegetable Processor & Juicer by
Taylor®. You will learn how to make the delicious and easy recipes that cut out
calories, but leave in all the taste. The juicer and recipes are great tools to get you
on track. There are over 125 more healthy and delicious recipes that you can find
in the Biggest Loser Cookbook. When you start eating right, you may feel better,
have more energy and feel empowered. For more information on NBC’s The
Biggest Loser, or to join The Biggest Loser Club, please visit the official Biggest
Loser web site at www.nbc.com/The_Biggest_Loser.com or www.biggestloser-
club.com
5
DESCRIPTIVE DIAGRAM
1. Juicer Head
2. Shaft
3. Plup Container
4. Working Bowl
5. Housing
8
1
2
6. Anti-DripValve
7. Gear Box
8. Plunger
9. Top Cover/
Fruit Tray
9
10. Feeding Funnel
11. Main Cover
12. Grater & Filter
Basket
13. Plup Container
14. Securing Clamp
15. Adapter
10
3
4
16. Motor Housing
17. Speed Control
18. Power Switch
19. Bottom Plate
20. Juice Cup
11
12
5
6
14
13
15
16
7
20
17
18
19
6
USING YOUR FRUIT AND VEGETABLE PROCESSOR & JUICER
BEFORE FIRST USE
•
Make sure the voltage in your outlet is the same as the voltage indicated on
the appliance. This appliance is for 120 –Volt AC electrical outlet only.
Remove any bags, labels or stickers from the appliance.
Clean the unit with a damp soft cloth
Wash all of the removable parts – container cover, plunger, feeding funnel,
grater/filter basket, using a sponge, warm water and mild dish detergent.
Rinse and dry carefully.
•
•
•
•
NOTE: do not immerse the base unit in water when cleaning
HOW TO USE YOUR FRUIT AND VEGETABLE
PROCESSOR & JUICER
•
Place the unit on a flat, sturdy surface with adequate clearance (i.e., do not
place under wall cabinets or on carpeting or other soft surfaces). This appli-
ance is not for use in convection or conventional ovens, microwaves, or on a
stovetop.
•
•
•
The extractor feature is used for firm fruits and vegetables, like carrots. The
citrus juicer is used for soft citrus fruits, lemons, limes, oranges, etc.
Always be sure that the appliance is properly assembled, turned on and run-
ning before inserting food.
Do not force feed the juicer. For most fruits and vegetables, a slow start/stop,
or jabbing motion will work best. If the juicer starts to vibrate, a slightly
stronger push with the firmer item should bring it into balance.
Firmer items are best used when the pieces are just large enough to fit in the
chute. Softer items are best used when cut into smaller pieces. Items with
thin skins (tomatoes/grapes) are best when chopped into even smaller pieces.
Stringy items like celery should be cut into roughly 2” long pieces for best
performance.
When making a drink that combines more than one fruit or vegetable, it is
recommended to alternate the various fruit or vegetable pieces when placing
them in the unit. For Example: Carrot/Celery/Tomato Juice – place a cou-
ple pieces of one vegetable into the juicer, then a couple of pieces of the sec-
ond vegetable, then the third vegetable. Repeat rotation until all pieces have
been placed in the juicer. This will provide better juicing results than juicing
all carrots, then all celery then all tomatoes.
•
•
•
When juicing leafy greens, it is recommended that you twist and roll the
greens into a ball the size of a golf ball. Always place the greens into the juicer
first, followed by firmer produce like carrots or celery. The juice from these
firmer vegetables will force additional juice from the greens.
7
•
When juicing soft produce like tomatoes or grapes, it is best to juice slowly,
pausing until the flow of juice has slowed down. The fiber of softer produce
can clog the holes in the juice basket, so you may have to empty the basket
more frequently. It is helpful to alternate with firmer produce.
When finished juicing, allow the appliance to run for a few minutes to allow
all juice to be extracted from the pulp.
It is important that you select fresh, firm and crisp produce for best juicing re-
sults.
Whenever possible, drink the juice at once. The sooner the juice is consumed,
the greater the benefit from vitamins and nutrients.
•
•
•
•
If storing the juice, use a glass container and add a few drops of lemon juice to
better preserve the juice. KEEP STORED JUICE REFRIGERATED.
USING THE EXTRACTOR
•
•
•
•
Assemble the appliance with the extractor components.
Make sure the appliance is switched off and unplugged.
Clean and wash the fruit or vegetables to be used.
Cut into appropriate sized pieces for feeding into the feeding funnel. Stones,
peel and pips should be removed from fruit.
•
•
•
Plug the appliance into the power outlet – remove the plug from its storage
area to the required length.
Flip the Top Cover/Fruit Tray over and use as a feeding tray for pushing fruits
and vegetable into the funnel with the plunger.
Start the juice extractor by pushing the power button. The corresponding
speed indication will light up. Choose position “l/ll” to select low or high
speed.
•
Insert the prepared fruit and vegetables into the feeding funnel and gently
push down with the plunger. NEVER USE YOUR FINGERS TO FEED
FOOD DOWN INTO THE FUNNEL.
•
•
•
FOOD MUST BE FED INTO THE APPLIANCE WHILE THE
MOTOR IS IN OPERATION.
Empty the pulp container and the juice container when full (this will probably
occur at the same time), before continuing to process more food.
You can make juice from different fruit and vegetables without having to
clean your juice extractor, as flavors are not transferred.
NOTE: Fruit andVegetable pulp can be used as ingredients in muffins, meatballs
and more! See the enclosed recipe booklet for ideas.
8
USING THE CITRUS JUICER
•
•
•
•
•
•
•
Assemble the appliance with the citrus juicer components.
Make sure the appliance is switched off and unplugged.
Be sure the securing clamps are safely locked before plugging in the unit.
Clean and wash the citrus fruit to be used.
Plug the appliance into the electrical outlet.
Slice the fruit into halves.
By simply placing the citrus fruit half onto the cone and pressing slightly, the
appliance will begin to operate and extract juice into the collecting container.
Use either the larger or smaller cone, depending on the size of the fruit to be
juiced. The larger cone is suitable for grapefruit and large oranges. The
smaller cone is best suited for small oranges, lemons and limes.
Open the non-drip valve in order for the juice to flow to the collecting cup.
•
•
CLEANING AND MAINTENANCE
After each use and before cleaning, unplug the appliance from outlet and allow the
unit to stop. DO NOT ATTEMPT TO CLEAN WHILE THE MOTOR IS
RUNNING OR THE COMPONENTS ARE STILL MOVING.
•
CAUTION: NEVER IMMERSE THE BASE UNIT, CORD OR
PLUG IN WATER
•
•
Open the securing clamps by pushing the release button.
Remove plunger, cover, pulp container and grater/filter basket and clean under
clear running water. A mild dish detergent may be used as well. If using deter-
gent, be sure to rinse and dry thoroughly.
•
If you have problems removing small particles from the grater/filter basket, a
small soft brush will remove remaining particles, (i.e. toothbrush, vegetable brush,
dish brush).
•
•
•
Dry all parts thoroughly.
To facilitate easier cleaning, rinse the filter immediately after use.
NEVER WASH THE BASE MOTOR UNIT. To clean the base, wipe clean
with a damp sponge and dry immediately. Never use excess water, treated cloths,
harsh cleaning agents, or sprays.
•
Reassemble all parts and store in a dry place.
9
TROUBLESHOOTING
The Fruit andVegetable Processor & Juicer will not operate.
•
•
•
Has a household fuse blown, or has a circuit breaker tripped?
Is the power supply cord properly seated in the outlet?
Has the cord been damaged in some way? If so, DO NOT USE THE AP-
PLIANCE. Contact Customer Service for replacement information.
Is the lid in place properly?
•
The Juicer is vibrating.
•
Are the components securely positioned in the base? If not, turn off the unit
and reposition the components onto the unit base. Be sure securing clamps
are safely locked into place.
•
Has the Juicer been overloaded? Attempting to process large quantities or
large pieces of fruit or vegetables may cause vibration. See section titled
“How to use your Fruit andVegetable Processor & Juicer.
The lid will not seat properly.
Is the product assembled properly?
•
Juice is not flowing to the collection container.
•
•
Is the anti-drip valve open to allow the juice to flow easily?
Is there any food blocking this valve?
Minimal citrus juice is in the collection container.
•
•
Are you using the correct sized cone?
Are you pressing firmly enough?
Juicing results are not what I expected.
•
•
•
Is the produce fresh, firm and crisp?
Have you removed stones and pips?
Note: individual preferences vary; you may need to experiment with juicing
combinations to achieve your desired results.
10
WARRANTY
Taylor® warrants this product to be free from defects in material or workmanship
for one (1) year for the original purchaser from date of retail purchase. It does not
cover damages or wear resulting from accident, misuse, abuse, commercial use, or
unauthorized adjustment and/or repair. If service is required, do not return to re-
tailer. Should this product require service (or replacement at our option), please
contact Taylor Customer Service at 1-800-289-0944.
There are no expressed warranties except as listed above.This warranty gives you
specific legal rights, and you may have other rights which vary from state to state.
If you need replacement parts:
•
Use only Taylor specified parts. These specified parts will fit right and work
right because they are made with the same precision used to build every new
Taylor appliance.
Keep this book and your sales slip together for future reference. You must provide
proof of purchase for warranty purposes.
For additional product information, or warranty information in Canada or else-
where outside the USA, please contact us through www.taylorusa.com
Taylor® is a registered trademark of Taylor Precision Products and its affiliated
companies.All rights reserved.
Made to our exact specifications in China. www.taylorusa.com
© 2008 The Biggest Loser is a registered trademark and copyright of NBC Stu-
dios, Inc. & Reveille LLC.All Rights Reserved.
11
AJ-1400-BL 8.08
|